Paul's 2.1Sd manual K47BAN. The early years.

The place to show off and tell us all about your XMs (or even other cars). Should it be a big project, or just some general pics, start your thread in here.
citroenxm
Global Moderator
Posts: 9983
Joined: Wed Apr 15, 2009 9:11 am
Location: North Wales - FAR far far away!!! :-p

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by citroenxm » Sat May 02, 2015 9:47 pm

Staying dean. im not allowed to sell her! The boss has spoken! :lol: :D

Enjoy one that i personally put effort into restoring. A lot of time but rewarding result.
Projects:(eventually if theres any bodywork left)
93 L Xm 2.1t D auto project
93 L xm V6 12v Sei Manual

Others
In use.. 1995 M reg S2 2.1td auto exclusive

User avatar
Dean
Global Moderator
Posts: 6116
Joined: Wed Apr 15, 2009 7:53 am
Location: Isle of wight

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by Dean » Sat May 02, 2015 9:53 pm

Excellent Paul, that's good news.

D
92 Citroen XM Prestige 3.0i Auto R.P5678
14 Mitsubishi L200 Trojan
89 Talbot Express 2.0 coach built Auto-trail Chinook

Addicted to Crackanory

Dieselman
Global Moderator
Posts: 13735
Joined: Thu Jun 18, 2009 6:44 pm

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by Dieselman » Sat May 02, 2015 9:56 pm

citroenxm wrote:Staying dean. im not allowed to sell her! The boss has spoken! :lol: :D
Sanctury.
92 2.1SED M.RP5740 ECZ Sable Phenicien
92 3.0 V6-24.Rp 5713 EXY Black
92 2.1SD M.RP 5685 ENT Blue Sideral
Prev
90 2.1SD M.RP 5049 EJV Mandarin
92 2.1SD A.RP 5698 EJV Mandarin
94 2.1SD A.RP 6218 ERT Triton Green
91 2.0SI M.RP 5187 EWT White

User avatar
russ92xmsed
Global Moderator
Posts: 5733
Joined: Mon Jun 11, 2012 5:23 pm
Location: Cheltenham
Contact:

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by russ92xmsed » Sun May 03, 2015 10:44 am

That's great news. Considering it's future was in doubt at one point, it's certainly found a good home.
Russ

1992 K reg XM 2.1 Auto SED RP 5712
1992 K reg XM 2.1 Auto SED RP 5705 (D)
Also
2003 C5 2.2 HDI Exclusive

I sell Engine bay, 1990 COTY, Total & Club XM Sticker Decals
http://www.rjwcreativedesign.co.uk

citroenxm
Global Moderator
Posts: 9983
Joined: Wed Apr 15, 2009 9:11 am
Location: North Wales - FAR far far away!!! :-p

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by citroenxm » Sun May 03, 2015 10:46 am

Done almost 3k in it already since her mot 2 months ago!!!
Projects:(eventually if theres any bodywork left)
93 L Xm 2.1t D auto project
93 L xm V6 12v Sei Manual

Others
In use.. 1995 M reg S2 2.1td auto exclusive

Dieselman
Global Moderator
Posts: 13735
Joined: Thu Jun 18, 2009 6:44 pm

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by Dieselman » Sun May 03, 2015 11:00 am

Cheap motoring.
92 2.1SED M.RP5740 ECZ Sable Phenicien
92 3.0 V6-24.Rp 5713 EXY Black
92 2.1SD M.RP 5685 ENT Blue Sideral
Prev
90 2.1SD M.RP 5049 EJV Mandarin
92 2.1SD A.RP 5698 EJV Mandarin
94 2.1SD A.RP 6218 ERT Triton Green
91 2.0SI M.RP 5187 EWT White

citroenxm
Global Moderator
Posts: 9983
Joined: Wed Apr 15, 2009 9:11 am
Location: North Wales - FAR far far away!!! :-p

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by citroenxm » Sun May 03, 2015 6:42 pm

Ok. Two jobs ticked off..

I forgot to list above the noisy and weakening wiper motor..

So firstly swapped the LH display..

Steering wheel off..
Image

This is how the display was showing..
Image

Ideally take the cowling off from around the stalks.. a tip here.. to ease getting the top cover off remove the plugs from the two stalks.. this gives better clearance for getting the top section out..

Now remove the heater front panel.. roatry panel..
Prise out the blower speed and air direction roatrys
Remove the two black screws..
Image

Pull the panel away the middle one will come with it. Pop out the slider lever too.

Image

Remove the four brass torx screws..

Theres two screws under the dash holding the front from below
Image

Image

Remove those..

Then theres two more hidden screws behind the central display.. under the speedo cover cowling..

Remove the two blanking covers
Image

Image

Take the screws out.. then slightly tricky lever the front edge upwards.. carefully..
Image

Image

Be carefull.. it can break and has on this one.. then prise up and towards you away from the clocks..
Image

Then the two hidden screws can be found..
Image

Remove the vents from the centre.. theres snap clips that need prising out to allow the front half housing the three displays towards you..
Image

Disconnect the clock and centre warning and LH display plugs and move it forwards.. theres no need to unplug the lower switchs..

Image
The display is held in with simmilar snap clips like the heater vent section over behind the centre vents..

Remove n replace..

Image

Ahhh thats better

Reassemble!!!

I also swapped out the wiper assey too

Scuttle trim off

Image

Ahh theres the blighter..
Wiper arms off.. 2x 13mm nuts.. the assey is held in by 3 10mm headded bolts.. thats all
Image

Image

Image

Tip.. for removing the assy from the scuttle area.. its a slight fiddle but if you pop off the arm for the nearside wiper it will all come out with a wiggle here n there..
Image

Refit... then press the arm back on.. reasemble

Two down..

Wheel bearing, glove box, and plipper and she be virtually perfect..
Projects:(eventually if theres any bodywork left)
93 L Xm 2.1t D auto project
93 L xm V6 12v Sei Manual

Others
In use.. 1995 M reg S2 2.1td auto exclusive

User avatar
Dean
Global Moderator
Posts: 6116
Joined: Wed Apr 15, 2009 7:53 am
Location: Isle of wight

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by Dean » Sun May 03, 2015 6:47 pm

Excellent Paul, you should split these and put them in the self help section.
She is coming along now.

D
92 Citroen XM Prestige 3.0i Auto R.P5678
14 Mitsubishi L200 Trojan
89 Talbot Express 2.0 coach built Auto-trail Chinook

Addicted to Crackanory

citroenxm
Global Moderator
Posts: 9983
Joined: Wed Apr 15, 2009 9:11 am
Location: North Wales - FAR far far away!!! :-p

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by citroenxm » Sun May 03, 2015 6:49 pm

Yes actually after i reviewed the post it looked quite good..

Its a pita to do all this on a mobile but managed to do it so far...
Projects:(eventually if theres any bodywork left)
93 L Xm 2.1t D auto project
93 L xm V6 12v Sei Manual

Others
In use.. 1995 M reg S2 2.1td auto exclusive

Vince
Citroen go-to-guy
Posts: 798
Joined: Sat Jan 23, 2010 4:29 pm

Re: Paul's 2.1Sd manual K47 BAN.. On the road

Post by Vince » Mon May 04, 2015 8:05 am

Great instructional post Paul.

I need to remove my display panel again and replace it with the one I got last time I was at yours. I will follow this to help me along :P

Post Reply