Lhm leak

Off topic chat about anything you like. Doesn't have to be about XMs (though they will inevitibly come up!). You can even discuss non-Citroens :o in here!
Post Reply
newxmman
Knows how to use the parking brake
Posts: 144
Joined: Tue Jan 22, 2019 5:53 pm

Lhm leak

Post by newxmman » Fri Dec 17, 2021 6:53 pm

Hi all, the bulb at the front middle, not the accumulator sphere the one in the middle back from that, would be probably under the dashboard, that type of position. It has the bulb on sideways, bulb end pointing towards the passenger side. Leak around there, we can’t see the source. Thought it was a couple of unions going into the part which has the bulb screwing into it and checked and sealed them. But still the leak is there and it isn’t light. Mass of pipes above the bulb, possibly from that area dripping down and to the left onto the floor. If I can’t cure it the lhm will run low very quickly so I must get it done but atm I’m at a loss. Diesel estate 92. Any ideas where I should be looking? Very thank ful.

User avatar
White Exec
Citroen God!
Posts: 6642
Joined: Fri Mar 11, 2011 7:38 pm
Orga / RP numbers: RP7165
1996 2.5TD saloon, Exclusive, Polar White
1992 BX19D Millesime, Sable Phenicien
Location: ex-Ealing, Cheshire, W.Sussex & Surrey. Now living in Sayalonga (Malaga, Spain)

Re: Lhm leak

Post by White Exec » Fri Dec 17, 2021 9:14 pm

Sounds like the front centre Hydractive sphere.
Leaks from there are usually not the high-pressure pipes/unions, but the low-pressure 3-4mm nylon return pipes, or the rubber elbows which connect them.
Check these returns first.
Chris
1996 XM 2.5TD Exclusive RP7165 Polar White
1992 BX19D Millesime RP5800 Sable
1989 BX19RD Delage Red Deceased; 1998 ZX 1.9D Avantage auto Triton Green Company car 1998..2001; 2001 Xantia 1.8i auto Wicked Red Company car 2001..2003

newxmman
Knows how to use the parking brake
Posts: 144
Joined: Tue Jan 22, 2019 5:53 pm

Re: Lhm leak

Post by newxmman » Fri Dec 17, 2021 9:33 pm

Thanks so much W E. I ll check that out, couldn’t see it first time. Can you tell me what makes them fail and can they be patched?

citroenxm
Global Moderator
Posts: 9981
Joined: Wed Apr 15, 2009 9:11 am
Location: North Wales - FAR far far away!!! :-p

Re: Lhm leak

Post by citroenxm » Fri Dec 17, 2021 9:34 pm

Rubber deteriation basicly.. With age..
Projects:(eventually if theres any bodywork left)
93 L Xm 2.1t D auto project
93 L xm V6 12v Sei Manual

Others
In use.. 1995 M reg S2 2.1td auto exclusive

User avatar
White Exec
Citroen God!
Posts: 6642
Joined: Fri Mar 11, 2011 7:38 pm
Orga / RP numbers: RP7165
1996 2.5TD saloon, Exclusive, Polar White
1992 BX19D Millesime, Sable Phenicien
Location: ex-Ealing, Cheshire, W.Sussex & Surrey. Now living in Sayalonga (Malaga, Spain)

Re: Lhm leak

Post by White Exec » Sat Dec 18, 2021 5:34 am

The rubber elbows are still available from Citroen, pt.no. 5280 P5.
Any perished 'straights', if needed, can be replaced with 3mm bore (thick wall) rubber tube.
Last edited by White Exec on Sat Dec 18, 2021 8:56 am, edited 1 time in total.
Chris
1996 XM 2.5TD Exclusive RP7165 Polar White
1992 BX19D Millesime RP5800 Sable
1989 BX19RD Delage Red Deceased; 1998 ZX 1.9D Avantage auto Triton Green Company car 1998..2001; 2001 Xantia 1.8i auto Wicked Red Company car 2001..2003

Dieselman
Global Moderator
Posts: 13734
Joined: Thu Jun 18, 2009 6:44 pm

Re: Lhm leak

Post by Dieselman » Sat Dec 18, 2021 7:40 am

If Lhm is leaking rapidly just due to having the engine running it will be a high pressure leak from one of the unions.
It's unlikely to be a failed pipe, but could be a joint not tight, or a failed pipe seal.

If the leak is general wetness and is noticeable over a prolonged time frame it is likely to be a return pipe leaking.
The return is from the height corrector and fluid flows whenever the corrector takes fluid out of the suspension system, to lower the ride height.

As said, it is likely to be the rubber elbow piece, the clear nylon pipes never leak.

It is unlikely to be from the Hydractive sphere, or valve block itself, unless the sphere is loose.

You're going to have to go under the car and clean up then observe.
92 2.1SED M.RP5740 ECZ Sable Phenicien
92 3.0 V6-24.Rp 5713 EXY Black
92 2.1SD M.RP 5685 ENT Blue Sideral
Prev
90 2.1SD M.RP 5049 EJV Mandarin
92 2.1SD A.RP 5698 EJV Mandarin
94 2.1SD A.RP 6218 ERT Triton Green
91 2.0SI M.RP 5187 EWT White

newxmman
Knows how to use the parking brake
Posts: 144
Joined: Tue Jan 22, 2019 5:53 pm

Re: Lhm leak

Post by newxmman » Sat Dec 18, 2021 10:08 am

Hi thanks all. The unions seem tight we ve addressed them. We have observed but we just can’t see where the leak is from. There is a mass of rubber pipes plus one smaller, it seems clear nylon pipe, which someone had a go at sealing with a black compound as the pipe disappears into its destination. That is the only obvious place that may have failed but we can’t see it leaking from there. Does anyone know how many rubber pipes there are and would it make sense to replace all of them in that area, how long are they to the elbows and where is there destination near the metal pipe Union. We just can’t see properly. We noticed the leak suddenly after a 4 mile drive, it was enough to make a small puddle. When the engine was just running there was wetness but not enough to see it squirting out from anywhere. When I got back home, the level of fluid had dropped by I suppose a cup full and when left overnight there was a small puddle about six inches diameter. That could be drips which had leaked while driving which then collected?

newxmman
Knows how to use the parking brake
Posts: 144
Joined: Tue Jan 22, 2019 5:53 pm

Re: Lhm leak

Post by newxmman » Sat Dec 18, 2021 6:55 pm

From that what would members guess?

Dieselman
Global Moderator
Posts: 13734
Joined: Thu Jun 18, 2009 6:44 pm

Re: Lhm leak

Post by Dieselman » Sat Dec 18, 2021 7:09 pm

I'd guess that you need to have a proper look, but it sounds like the return pipe union has split.
92 2.1SED M.RP5740 ECZ Sable Phenicien
92 3.0 V6-24.Rp 5713 EXY Black
92 2.1SD M.RP 5685 ENT Blue Sideral
Prev
90 2.1SD M.RP 5049 EJV Mandarin
92 2.1SD A.RP 5698 EJV Mandarin
94 2.1SD A.RP 6218 ERT Triton Green
91 2.0SI M.RP 5187 EWT White

newxmman
Knows how to use the parking brake
Posts: 144
Joined: Tue Jan 22, 2019 5:53 pm

Re: Lhm leak

Post by newxmman » Sat Dec 18, 2021 7:23 pm

Fine thanks, so I can home in, where is it, looking up near the bulb?

Post Reply