L592 EVN formerly J2 CXM

[nimspringus]

In terms of the sill panel, we're pretty pleased with the quality of them. Unfortunately lots of little plates had to be put in before we could even think about attaching the sill at all as there were so many gaps where the original metal was joined.
It's on now, though, so that's *almost* one side done.

Honestly unsure of how the car got this bad. Like I say, it wasn't just the sills, but up inside the front arch as well. The worst of the rot is all on the passenger side, although a bit of digging yesterday revealed the front of the driver's sill and floor is also completely shot. That'll get addressed in a couple months' time.

I have a source for a full sunroof cassette, so that's not a problem. In the meantime I'm just taping around the seal to stop any more ingress.

If the car hadn't been so mechanically sorted, I wouldn't have taken it on to be honest.

[Dieselman]

I have a source for a full sunroof cassette, so that's not a problem. In the meantime I'm just taping around the seal to stop any more ingress.

I would try to repair every item that isn't right, spares for Xm are running out. Too many people still have the swap it and bin it mentality, which means everybody is going to run out of parts even quicker.

If people keep being parts jockeys on rare cars, including Xm, they will find out the hard way it was the wrong modus operandi.

[Julianw]

I have a source for a full sunroof cassette, so that's not a problem. In the meantime I'm just taping around the seal to stop any more ingress.

I would try to repair every item that isn't right, spares for Xm are running out. Too many people still have the swap it and bin it mentality, which means everybody is going to run out of parts even quicker.

If people keep being parts jockeys on rare cars, including Xm, they will find out the hard way it was the wrong modus operandi.

Couldn't agree more. Romping through what spares are available, often replacing parts that aren't at fault because a diagnosis is incorrect is almost as bad as scrapping the whole car because something like an alternator is not available off the shelf. I have every respect for those that make an effort to repair or refurbish a part rather than bin it at the drop of a hat, just because a replacement is available at the time...